INSTALLATION ANDOPERATIONS MANUALGRN110G4GRP110G4GRN150G4GRP125G4

Page 81285-0060708-153 Supply Primary Secondary Generator Tank Regulator Regulator Set 1 2 3 4TWO (2) REGULATO

60708-153Page 91285-00CAUTION – PERSONAL DANGERCAUTION - NEVER dispose of a battery in a fire. The battery iscapable of exploding.CAUTION -DO NOT open

Page 101285-0060708-153INSTALLATION NOTESBecause of the many different types of service, feeder, anddistribution equipment, no specific wiring instruc

60708-153Page 111285-00 ****************** WARNING ***** ************* A main line circuit breaker has been provided inside thegenerator hous

Page 121285-0060708-153Zenith ATSThe terminal markings in the Zenith ATS are marked “X1” and“X2”. The wire labeled “Start 1” is routed to start cont

60708-153Page 131285-00STARTING PROCEDUREMANUAL MODE********************* WARNING *********************EQUIPMENT DAMAGE - BEFORE ATTEMPTING TO START

Page 141285-0060708-153TROUBLESHOOTING TABLESNote: Before doing any troubleshooting, check the digitaldisplay on the DGC-2020. Normally it will tell w

60708-153Page 151285-00SPECIFICATIONSMODEL: GRN110G4GRP110G4ENGINE; 8.1 liter GM Turbocharged1800rpmFUEL REQUIREMENTSGRN110G4 NATURAL GAS 1,651,000 b

60708-153Page 161285-00APPENDIX 1The table below is based on Table 310.16 in the National Electric Code 2011 EditionAllowable ampacitier of insulated

60708-153Page 171285-00THREE PHASE AC WIRING - DELTASINGLE PHASE AC WIRINGSINGLE PHASE120/240 VOLTSTHREE PHASE -DELTA120/240 VOLTS

Page iTABLE OF CONTENTSINTRODUCTION iGUIDE TO PRODUCT SAFETY 1BASIC INFORMATION 2Description 2Specifications 3Engine Control Layout 3DSE-7X10 Panel

Page 181285-0060708-153THREE PHASE AC WIRINGHIGH AND LOW WYETHREE PHASE-LOW WYE120/208 VOLTSTHREE PHASE-HIGH WYE277/480 VOLTS

60708-153Page 191285-00VOLTAGE REGULATOR WIRINGTHREE PHASE AND SINGLE PHASE

60708-153Page 201285-00ENGINECONTROLSCHEMATIC

1285-0060708-153Page 21INSTALLATION DRAWINGGRN150G4 & GRP125G4GRN110G4 & GRP110G4

60708-153 - 1285-00225 S. CordovaLe Center MN 56057Phone - 507-357-6707www:winpowerinc.comLimited WarrantyWINPOWER, Incorporated warrants to the orig

60708-153Page 11285-002. FIRE HAZARD - LP and NG fuel presents a hazard ofpossible explosion and/or fire if not properly handled.a. Do not smoke or us

Page 21285-0060708-153TESTING POLICY:Before any generator is shipped from the factory, it is fullychecked for performance. The generator is loaded to

60708-153Page 31285-00The rated power of each engine-generator is limited by thetemperature, altitude and all other ambient conditions specifiedby the

Page 41285-0060708-153A. USB PROGRAMMING PORT - USB port for computerinterface. Used for programming the DSE7X10 controller.B. DSE7X10 CONTROLLER - S

60708-153Page 51285-00***** CAUTION **** EQUIPMENT DAMAGE - These units are shipped with oil,and a 50/50 mix of coolant. Be sure to check all fluid

Page 61285-0060708-153The generator set can be lifted with properly rated chains or cablesalong with the use of spreader bars. The spreader bars shou

60708-153Page 71285-00Do not shock mount the main frame. Engine vibration will betransmitted to the control panel causing erroneous start/stopcycles